Product ID:651 DETERGENT LUBRICATING OIL (AEROSOL)
MSDS Date:01/31/1994
FSC:9150
NIIN:00N088354
MSDS Number: CHLYV

A W CHESTERTON CO

225 FALLON RD
STONEHAM, MA 02180-2999
US

Emergency Phone: 800-535-5053

Info Phone: 617-438-7000

Cage: 71431

CHESTERTON A W CO

STONEHAM, MA 02180-9101 US

Telephone: 781-438-7000/800-535-5053

Cage: 71431

0.03.

CAS: 108419-35-8

Fraction By Weight: 5-10%

OSHA PEL N/K

ACGIH TLV: N/K

>760.

CAS: 124-38-9

RTECS: FF6400000

Fraction By Weight: 1-5%

OSHA PEL 5000 PPM

ACGIH TLV: 5000 PPM; 30000 STEL

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE EFFECTS: DIRECT EYE CONTACT
CAUSES EYE IRRITATION. HIGH VAPOR CONCENTRATION CAN CAUSE EYE AND
RESPIRATORY IRRITATION, HEADACHE AND DIZZINESS. CHRONIC: PROLONGED
OR REPEATED SKIN CONTACT MAY DEFA T THE SKIN AND CAUSE SKIN
IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, ADMINISTER
ARTIFICIAL RESPIRATION. CONTACT MD. SKIN/EYE CONTACT: WASH SKIN
WITH SOAP AND WATER. FLUSH EYES FOR AT LEAST 15 MINUTES WITH LARGE
AMOUNTS OF WATER. CONTACT MD IF IRRITATION PERSISTS. INGEST: DO
NOT INDUCE VOMITING. CONTACT MD IMMEDIATELY.

Flash Point Method:CC
Flash Point:260F,127C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . COOL EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:PRESSURIZED CONTAINERS WHEN HEATED ARE A
POTENTIAL EXPLOSIVE HAZARD.

Spill Release Procedures:EVACUATE AREA. PROVIDE ADEQUATE VENTILATION.
CONTAIN SPILL TO A SMALL AREA. FLUSH AWAY FROM IGNITION SOURCES
WITH WATER. PICK UP WITH ABSORBENT MATERIAL AND TRANSFER TO A
SUITABLE CONTAINER FOR DISPOS AL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT STORE IN DIRECT SUNLIGHT OR
ABOVE 49C(120F).
Other Precautions:THIS IS A PETROLEUM BASE LUBRICANT. AS WITH ANY
SIMILAR PRODUCT, IF SWALLOWED IN LARGE QUANTITIES THIS PRODUCT
COULD BE HARMFUL OR FATA. PROLONGED SKIN CONTACT AND EXCESSIVE
INHALATION OF THE SPRAY MI ST SHOULD BE AVOIDED.

Respiratory Protection:NOT NORMALLY NEEDED. IF CRL IS EXCEEDED, USE
NIOSH APPROVED ORGANIC VAPOR RESPIRATOR.
Ventilation:NO SPECIAL REQUIREMENTS. IF CRL IS EXCEEDED, PROVIDE
ADEQUATE VENTILATION.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.

Boiling Pt:B.P. Text:464F,240C
Vapor Pres:SEE INGS
Vapor Density:>1
Spec Gravity:0.9
Evaporation Rate & Reference:<1 (ETHER=1)
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:11

Stability Indicator/Materials to Avoid:YES
CAUSTICS, STRONG OXIDIZERS LIKE LIQUID CHLORINE AND CONCENTRATED
OXYGEN.
Stability Condition to Avoid:OPEN FLAMES AND RED HOT SURFACES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OTHER TOXIC FUMES.

Waste Disposal Methods:INCINERATE OR BURY ABSORBED MATERIAL. DO NOT
INCINERATE PRESSURIZED CONTAINERS. CHECK LOCAL, STATE AND FEDERAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.